1974-76 Model Merc 500

General Information:

• This model was painted all "Phantom Black."
• The serial number was on a plate riveted to the swivel bracket above and between the clamp screws..
• Serial numbers 3816308 thru 4140999 were 1974 models.
• Serial numbers 4141000 thru 4357639 were 1975 models.
• Serial numbers 4357640 thru 4576236 were 1976 models.
• 1974-76 Merc 500's were produced in Merc 500M (Manual Starting, Short Shaft,) Merc 500ML (Manual Starting, Long Shaft,) Merc 500E (Electric Starting, Short Shaft, with Alternator) and Merc 500EL (Electric Starting, Long Shaft, with Alternator)

Some items we have available for this model:

• Parts List 90-56972 (1974 models)
• Parts List 90-71732 (1975 models)
• Parts List 90-74962 (1976 models)
• Owners manual 90-85246
• Dealer service manual 90-68647 (1974 models)
• Dealer service manual 90-75512 (1975-76 models)
• Consumer service manual SEL1406
• Emergency Starter Rope 47341A11 (electric start models)
• Starter Rope 50-12066T9 (manual start models only)
• Starter Handle 28747 (manual start models only)
• Recoil Starter Spring 24-39502T02 (manual start models only)
• Starter Motor Kit 50-55601A2 (for electric start models)
• Powerhead Gasket Set 27-72486A32
• Standard Piston Rings 39-27841 (12 per engine)
• Top Crankshaft Seal 26-41953
• Bottom Crankshaft Seal 2 of 26-41953
• Spark Plug L76V  (1974-75 models)
• Spark Plug L78V  (1976 models)
• Spark Plug Wires 84-63212A2 (1974-75 models)
• Spark Plug Wires 47899A9 (1976 models) (4 per engine)
• Timing Belt 20140 (1974-75 models)
• Rotor 333-3143 (1974-75 models)
• Coil Wire 84-821945A8 (1974-75 models)
• Ignition Switch Box 333-3213A3 (1974-75 models)
• Ignition Stator 398-832075A20 (1976 electric start models)
• Ignition Trigger 96452A4 (1976 electric start models)
• Ignition Coil 339-5288T2 (1976 electric start models) (4 per engine)
• Ignition Switch Box 332-5772A7 (1976 electric start models)
• Carburetor Rebuild Kit 1395-9258A1 (1974-75 models)(2 per engine)
• Carburetor Rebuild Kit 1399-5199-1 (1976 models)(2 per engine)
• Carburetor Gasket Kit 1399-5198 (1976 models)(2 per engine)
• Carburetor Float 1395-8673 (1974-75 models)(2 per engine)
• Carburetor Float 1395-9293 (1976 models)(2 per engine)
• Fuel Pump Rebuild Kit 21-30430A1 (1974-75 models)
• Fuel pump Diaphragm & Gasket Kit 1399-5137 (1976 models)
• Fuel connector for remote fuel line to plug into engine 22831T3
• Tilt Adjusting Pin 17-49930A1
• Connecting tube for tilt rests 47802
• Lower Unit Driveshaft Seal 1 of 26-90562 and 1 of 26-79831
• Lower Unit Prop Shaft Seal 26-56788 (1974 models)
• Lower Unit Prop Shaft Seals 1 of 26-69188 & 1 of 26-69189 (1975-76 models)
• Water Pump Impeller 47-89983T
• Aftermarket Water Pump Impeller Kit (impeller, gaskets, wear plate, etc.) 47-89983K
• Mercury Water Pump Kit (includes pump housing) 46-60366T1
• Lower Unit Seal Kit 26-90562A1
• Gear Lube 92-802844A1
• Prop Nut 11-826711-20 (1974 models)
• Prop Nut 11-69578T1 (1975-76 models)
• Trim Tab Anode 31640T4
• Phantom Black Paint 92-802878--1  
• Many additional parts, please inquire!

In addition, the following USED items may be available:

• Front Cover